Dillon EDjunior (Old) Manuel d'utilisateur

EDjunior Dynamometer and Crane ScaleUser Instructions29810-0017 Issue AG Sept. 2012

10 EDjunior Dynamometer User Instructions3 EDjr Description3.1 EDjr Front PanelThe EDjr comes in several weight capacities. All have the same front p

EDjunior Dynamometer User Instructions 11 3.1.1 EDjr KeysThere are four “hard” keys and four “soft” keys. The hard keys are permanently labeled and

12 EDjunior Dynamometer User Instructions4 Power On and AnnunciatorsWhen you power up the EDjr you will see a display similar to the example shown on

EDjunior Dynamometer User Instructions 13 5EDjr SetupOne of the first things you should do to begin using the EDjr is to set it up to suit your spec

14 EDjunior Dynamometer User InstructionsThere is a keypad shortcut for increasing and decreasing contrast. While in normal display mode press Arrow

EDjunior Dynamometer User Instructions 15 Keys Press this key to perform key tests. Any key pressed will be reflected in the display. Press to end

16 EDjunior Dynamometer User Instructions6 EDjr Operation6.1 Display ModesThe EDjr has two display modes accessible by pressing the Mode soft key. Se

EDjunior Dynamometer User Instructions 17 6.4 Displaying Peak ForceThe EDjr will store the peak force applied until that reading is cleared. To disp

18 EDjunior Dynamometer User Instructions6.5 Calculating Tension in a SystemThe setup shown above will give you an approximate tension reading. This

EDjunior Dynamometer User Instructions 19 7 TroubleshootingProblem Possible Cause SolutionEDjr powers on momentarily and turns offLow batteryBad key

© Avery Weigh-Tronix, LLC 2012. All rights reserved. No part of this publication may be reproduced, stored in an electronic retrieval system, or trans

20 EDjunior Dynamometer User Instructions8 Weighing and Force Measurement PracticeThe basis for all electronic force measurement or weighing is measu

EDjunior Dynamometer User Instructions 21 Figure 8.1 Good force measurement practiceCenter the loadon the shackle pin.Use spacers toinsure centerin

22 EDjunior Dynamometer User Instructions

Overload Protection and Overhead Weighing EquipmentFairmont, Minnesota U.S.A.Toll-Free: (800) 368-2031Phone: (507) 238-4461Fax: (507) 238-8258www.dill

E1070 Indicator Service Manual 3 Table of ContentspageChapter 1 General information and warnings ...

4 E1070 Indicator Service Manual

EDjunior Dynamometer User Instructions 5 1 General information and warnings1.1 About this manualThis manual is divided into chapters by the chapter

6 EDjunior Dynamometer User Instructions1.2 Installation1.2.1 Safe handling of equipment with batteries1.3 Safe OperationKeep all the following in mi

EDjunior Dynamometer User Instructions 7 Safety is always a concern in overhead lifting and tensioning applications. To limit your liability always

8 EDjunior Dynamometer User Instructions1.4 Routine maintenance1.5 Cleaning the machine1.6 TrainingDo not attempt to operate or complete any procedur

EDjunior Dynamometer User Instructions 9 2 IntroductionThe EDjuniorTM (EDjr) electronic dynamometer from Dillon is a force measurement load sensor a